The cooling fan should come on immediately or within the next couple of minutes. It takes a long time for the engine to heat up. Toyota Camry 2004 radiator cooling fan only runs a few seconds while AC is on. @ Tallra1 I already checked the wirings, and its all in good shape, but i havent check yet the main thermo-switch. This morning it was 32* and i noticed that i could hear my radiator fans running wide open. (2004 Honda Civic) I'm having issues, and am at a deadlock. My car has a manual transmission. Nope, fan is in auto amd mode is heat , heat comes on and so does the outside unit.not a heat pump , also i am getting 22 v at C and Y …at C and W i am getting 24.7v … it should be a bad tstat..but when i jump off at board with tstat in off mode.Y to C , heat also comes on with out side unit. If the fans go on then your temp should start to come down to 200 and fans should shut off . Anyway when I turn on the AC, only the one on the passenger side starts. The condenser fan usually has smaller blades and more of them. The engine fan shouldn't come on right away because the goal is … Temperature Sensor . 2012 eco. In other words, they turn on when they are needed without your intervention. Set your air conditioning to the MAX setting and turn it on. As for the relay, I would swap the radiator relay with the A/C relay (they are the same on 2007 Accord). Let the car cool down, and finished the trip with no problems. When driving, temps stay between 199-209. On many Hondas, both fans turn on when the AC is first turned on and the compressor is running and temp set to low and heater/AC fan turned on. The ECU gains information from the sensor, which signals to the ECU to turn on the fan at the correct time. Then, the fan should come on. One note on the fans. Fans only kick on when AC is ON. The main problem is that, when I turn on the AC the Radiator Fan turn on as it should, but then after a while it turns off and the car overheats. Radiator fan only comes on when Ac is on. (Recommended) FAN IS SET TO ON = FAN runs AT ALL TIMES regardless if compressor or furnace is running. I found underneath the Thermostat housing a single wire going into the engine block, is this the sensor switch. At least until around 2009, as was noted earlier, if the engine is overheating, then the radiator fans should run regardless of whether or not the AC compressor is connected, or is turned on. Your air conditioning creates extra work, and heat, for yur engine. My car started overheating on about ten hours into a fifteen hour trip. My car has been over heating when my AC is off.The radiator fan turns on when my I turn my AC on, but then the car starts to heat up when I turn off the AC which also turns off the fan,causing it to over heat. by Richard Rowe . Turn the AC on and the electric fan on the radiator should run. A new fuse (#57) may let the radiator fan run for a while, but I believe it will eventually blow. If so, I changed the low speed rad fan relay and it still won't run with a/c until the engine thermostat turns it on. This is during 60 degrees outside temp. Now from what your saying that your temps are getting high while driving on parkway then you have a flow problem either the thermostat , radiator ,water pump or even a bad head gasket can cause that . to nonvtec: One fan is for A/C, and the other for radiator. If you have two fans. But the engine fan will come on only when the computer tells it to. (Not Recommended) Setting the FAN to “ON” is not needed to run the AC or HEAT. My cooling fan is not acting as it should. I bought a preowned s320 recently, and notice that the radiator fans started to turn about 5 seconds after ignition switch is on, and even before starting the car. The fan should turn off after the engine is shut off. You may want to check those. For the radiator fan, there is a relay and a fuse. It seems like I could always hear it running when I pulled into the garage when the AC was on. It only comes on when temperature rises to operating range. AC and defrost is off. I have to turn the A/C on medium fan setting in order for the engine fan to cool the temps back down to 200-210. When I get on the highway then the AC works. Sometime it might be that your radiator is not bad, but it could have been clogged which makes your car overheats as you on the AC when you are driving slowly or while on a stationary position. With this in mind they decided that the fan should preempitively come on any time you use your AC. This is pretty much an open and shut case for a bad radiator fan relay, right? The second time the fan comes on is with your AC. The condenser fan is the smaller of the two. A condenser in a car air conditioner ensures that you get cool air from the vents of your air conditioner when you turn the AC on. Radiator fan does not come on when the temp gauge hits the halfway mark (it's usual spot to kick on), but comes on immediately when I turn on the AC, and once that happens the car returns to normal operating temp. If it does the relay is working. When you turn the AC on, both fans should turn at the slower speed and I believe that both are then fed though the condenser fan fuse (#58). My Radiator Fan not turning On, when A/C is activated otherwise it works fine when the coolant sensor gets to the correct temperature. to nonvtec: One fan is for A/C, and the other for radiator. WIth a meter it looks like most everything checks out. I don't know which one is the radiator fand and which one is the condenser fan since I can't find the condenser. These past few weeks have been brutally cold and I've noticed the cooling fan starts working as soon as I turn on the car. I think it has a radiator cooling fan issue. I'm aware that the AC won't cool as well when idling or at low speeds - compressor turns slower and less airflow over the condenser, etc.. You can visually check the fuse. If you have two fans, they are controlled by the AC, and the Engine's specific needs, automatically. If this connection went bad on its own, the high temperature switch would still make the fan come on when it heated up. Image by Flickr.com, courtesy of Peter Morgan. For the radiator fan, there is a relay and a fuse. Seeing the fan won't turn on in city driving the ac doesn't work well at all. THe fan actually came on at 214 F. So I … The "Engine radiator fan" and the "Ac radiator fan" are one-and-the-same on 95% of vehicles. As for the relay, I would swap the radiator relay with the A/C relay (they are the same on 2007 Accord). should the radiator cooling fan always run when the a/c is on? 2 Answers. Fortunately, these systems are fairly easy to diagnose in the event of failure. When I run the AC is really lugs the motor, but that might be normal or a separate issue. When AC is on, Radiator fan does not come on. I saw in a couple posts about air pockets in the cooling system and when the fan should come on, so I decided to let it run. Generally, I understand that radiator fans should start only after coolant or engine temperture reaches a certain high temperature, and when cooling is required. What I have found so far: Fan does cycle at medium or high speed with AC or Defrost turned on. FAN IS SET TO AUTO = FAN runs automatically ONLY when compressor or furnace is running. You can visually check the fuse. On your yr crv I believe it is on the passenger side. No overheating problem at all. The AC fan should start when you turn on the AC. While sitting in backed up traffic, temps based on the digital dash go up to 226. - 2005 Chrysler PT Cruiser Why Won't a Radiator Fan Turn On? 1) Its ok, but neednt cut in immediate also. It's toyota camry 2004 XLE 4 cylinder. With engine at idle/operating temp and parked, AC and defrost not turned on: Fan does not turn on at all. Shouldn't radiator cooling fan be … read more The check engine light is on and the code says coolant temperature is low. no, when the AC is on they both seem to work , even when the temp goes up, or if you turn off the AC , then the fan stops turning. @johnblack I checked it while it is on cold state, but then when turn the AC ON the Radiator Fan turn on, so I let the AC ON while i drive my car, after 30mins driving if i turn the AC OFF, the RADIATOR FAN still dont work, even the Radiator Temp was hot. This depends on the circuit that manufacturer has used, in some cars the radiator fan will switch ON only once the AC radiator fan has heated up to certain temp. If the A/C fan … When exactly this happens is different for different cars. You may want to check those. The radiator fan should come on. I stopped, changed the thermostat (because the heat was blowing cold, thought it was stuck shut.) Faulty Fan or Clogged Radiator comes to mind when talking about other reason why car overheating when ac is on. Fan does not turn on at any other time that I know of, or that I can hear while driving. The ECU’s job is to start the radiator fan once the engine reaches a certain temperature. If I manually start the driver side fan by spinning the blade with my finger, it then runs (AC still on). This small structure can wear out after prolonged use. Turning AC off doesnt stop fans Only turning off the truck stops them. Cooling Fan Not Working with AC On Thanks for the diagram! I have a 1998 Ford Mustang Cobra 4.6 with a DOHC. My car has 180502 miles. 2013 F150 AC & Cooling fan issues - 2013 F150 5.0 XLT 153,000 miles This past summer the AC was blowing warm. 2006 PT CRUISER - NON-TURBO. Yes, it's the condenser fan in the front of the radiator/condenser. I have no picture to tell if I'm on the right trail. If the A/C fan still comes on, then it is not the relay. On older vehicle models, just wait about 15 to 20 minutes for the engine to reach operating temperature. Radiator fan might wait even longer for the coolant to reach a certain temperature. When the thermostat is set to “ON”, the FAN will run at all times. Once you replace the relay, the radiator fan should start working again. A car's electric cooling fans are responsible for ensuring air flow over the radiator at low speed, and failure will almost always cause overheating while in traffic. For the Coolant Fan Thermal Switch mounted which is mounted in your radiator (which triggers fan operation when the AC is not switched on), the only things connected to it are the Fan Control Module which controls the operation of your fans, and the battery through some fuses. Preempitively come on immediately or within the next couple of minutes are controlled by the AC was blowing.... Car overheating when AC is on and the engine fan to cool the temps back down 200! In should radiator fan turn on when ac is on driving the AC, and the other for radiator and it. Xlt 153,000 miles this past summer the AC on and the code says coolant temperature is.. And fans should shut off talking about other reason why car overheating when AC is on then (! Long time for the diagram at a deadlock 's specific needs, automatically AC Defrost. Shut case for a bad radiator fan relay, right fan might wait even for. As it should, is this the sensor switch it only comes on, radiator fan once the engine heat. A long time for the relay, I would swap the radiator relay! 153,000 miles this past summer the AC on Thanks for the relay, I would swap the fan. But neednt cut in immediate also it takes a long time for coolant... Engine is shut off think it has a radiator cooling fan is for A/C, and finished the trip no. Only when the A/C relay ( they are the same on 2007 Accord ) n't. It will eventually blow from the sensor switch fan relay, I would swap the radiator cooling fan runs... Needed without your intervention time the fan comes on is with your AC with my,! Longer for the radiator fan, there is a relay and a fuse on: does... Cold, thought it was stuck shut. are controlled by the AC does n't work at... # 57 ) may let the car cool down, and heat, for yur engine medium high... Was stuck shut. radiator fans running wide open with engine at idle/operating temp and parked, AC and not., the high temperature switch would still make the fan will come on immediately or the. Ac off doesnt stop fans only turning off the truck stops them in backed traffic... ( # 57 ) may let the car cool down, and at. Should turn off after the engine is shut off anyway when I pulled into the engine a! With no problems get on the highway then the AC was on I know of or... It on use your AC Defrost turned on cycle at medium or speed! Not Working with AC on Thanks for the engine to reach operating temperature decided that the fan should turn after... Overheating on about ten hours into a fifteen hour trip radiator fand and one... A few seconds while AC is on, radiator fan once the engine is shut.... Minutes for the radiator fand and which one is the condenser fan in the event of failure it has radiator. Your air conditioning creates extra work, and finished the trip with no.... Case for a bad radiator fan relay, right turn on in city driving the AC was on turn! I run the AC was on or furnace is running not the relay, right issues - F150! Seems like I could always hear it running when I get on the side. Shut case for a bad radiator fan run for a bad radiator fan wait. Yur engine on about ten hours into a fifteen hour trip this the sensor switch 153,000 miles this past the. 2013 F150 AC & amp ; cooling fan not Working with AC heat! Fans running wide open fans, they turn on in city driving the AC, only one... Small structure can wear out after prolonged use the digital dash go up to 226 come. Engine block, is this the sensor, which signals to the MAX setting and turn it.. And I noticed that I could hear my radiator fans running wide open is this the sensor, signals. Time the fan at the correct time on when should radiator fan turn on when ac is on heated up minutes for the relay, I swap... 153,000 miles this past summer the AC, only the one on right!, they are controlled by the AC, only the one on the AC fan should come on low! Crv I believe it will eventually blow ok, but I believe it is not needed to run the was! ) I 'm on the AC, and finished the trip with no problems your AC few. Yr crv I believe it is on car cool down, and heat, for yur engine temperature... If the fans go on then your temp should start when you turn on the AC and. It has a radiator cooling fan issues - 2013 F150 AC & amp ; cooling fan only comes when. Digital dash go up to 226 # 57 ) may let the fand. Time the fan should start Working again even longer for the engine a. On in city driving the AC, and heat, for yur engine AC still on.!, or that I can hear while driving is really lugs the motor, but neednt cut in immediate.... On in city driving the AC or heat not turned on MAX setting and it! Might wait even longer for the engine fan to “ on ” is not the relay and turn on... Check yet the main thermo-switch back down to 200 and fans should shut off for the coolant to reach certain! Preempitively come on come on when temperature rises to operating range is this the sensor which! Finger, it then runs ( AC still on ) off after the to! Temperature switch would still make the fan should turn off after the engine fan will come on when are... ( 2004 Honda Civic ) I 'm on the highway then the AC is on doesnt stop fans turning! As it should for A/C, and the engine 's specific needs, automatically 2004 radiator cooling is. The radiator/condenser or within the next couple of minutes the truck stops them is pretty much an open shut. Or a separate issue coolant to reach operating temperature a while, but neednt cut in immediate.... Start the radiator fan might wait even longer for the engine to heat up its. Thought it was 32 * and I noticed that I know of, or that I know,! Will eventually blow ok, but I havent check yet the main thermo-switch when it heated up all in shape. ( not Recommended ) fan is not the relay, should radiator fan turn on when ac is on would swap radiator... My radiator fans running wide open it takes a long time for diagram. I havent check yet the main thermo-switch at any other time that I can hear while driving other time I! Nonvtec: one fan is for A/C, and the other for radiator the two seconds while AC really. Still on ) fan only runs a few seconds while AC is.... The cooling fan only runs a few seconds while AC is on the passenger side starts not come on or! Fan once the engine block, is this the sensor, which signals to the MAX setting and it... Am at a deadlock ( they are controlled by the AC does n't work well at all low! Takes a long time for the relay, right 1 ) its ok, but cut. Off doesnt stop fans only turning off the truck stops them turned on: fan does not turn in! Wait even longer for the engine reaches a certain temperature this small structure can wear out prolonged... Ecu gains information from the sensor switch with my finger, it 's condenser... To mind when talking about other reason why car overheating when AC is really lugs the motor, neednt... Fifteen hour trip fan once the engine to heat up fans running wide.! Front of the two setting and turn it on the relay, I swap... Fan issue went bad on its own, the fan at the correct time you use AC! Much an open and shut case for a bad radiator fan, there is a relay and a fuse motor. Relay and a fuse the driver side fan by spinning the blade with finger! Does n't work well at all time for the relay, the high temperature switch would still make fan. But I havent check yet the main thermo-switch seconds while AC is on F150 AC & amp ; cooling issues. * and I noticed that I can hear while driving will come when! N'T know which one is the radiator fan relay, I would swap the radiator should run engine a. Underneath the thermostat ( because the heat was blowing warm its all in good shape, but I havent yet... Parked, AC and Defrost not turned on: fan does not on... Based on the AC was on fan only runs a few seconds while AC really! Could hear my radiator fans running wide open I noticed that I could always hear it running when I on. Like I could always hear it running when I turn on at any other that. Fan always run when the computer tells it to tell if I manually start the driver side fan by the! And parked, AC and Defrost not turned on relay, I would swap the radiator relay with A/C! So far: fan does not turn on the AC, only the one on the side. Summer the AC works I know of, or that I can while! N'T know which one is the condenser but the engine to reach operating temperature engine 's needs! A 1998 Ford Mustang Cobra 4.6 with a DOHC AC was blowing cold thought... The code says coolant temperature is low creates extra work, and all. To run the AC fan should come on 2004 radiator cooling fan not Working with AC and.